Eaton Fuller Sgàineadh Code 4 Motor / Generator Chuairteach Gaoithe Sensor

Sgàineadh code for Eaton Hybrid Drive Siostaman modailean (MY08) EH-8E306A-U, EH-8E306A-UPG, EH-8E306A-UP, EH-8E306A-CD, EH-8E306A-T, EH-6E606B-CD, (MY09) EH-8E406A-U / D, EH-8E406A-UP, EH-8E406A-UPG, EH-8E406A-CD, EH-8E406A-CDG, EH-8E406A-CDR, EH-8E406A-T, EH-6E706B-CD, EH-6E706B-P agus EH-6E706B-UPG. The Motor / Generator Chuairteach Gaoithe Sensor tha muin gu cùl na Motor / Generator air feadh an Input Cas. Tha sensor (dà phìos dealbhadh) 'S e roth muin gu Input Cas, agus a' mothachdainn Ring muin gu charbadan taigheadas. Tha mothachdainn Ring a sholar le bholtaids-ìosal rè obrachadh. Tha a 'tionndadh roth tuainealach bholtaids a-steach atharrachaidhean an mothachdainn Ring, a tha an uair sin atharrachadh gu didseatach comharra airson Motor / Generator RPM. Bholtaids a 'cur a-mach agus an tricead a tha ìosal ann an leisg agus a' meudachadh le RPM.

Sgàineadh Code 4 – Motor / Generator Chuairteach Gaoithe Sensor Lorgaidh

  • Inverter Ignition bholtaids a tha nas motha na 7 volts agus nas lugha na 16 volts.
  • IMF 2 Chan eil shuidheachadh ma tha gnìomhach Transmission Input Cas Gaoithe Sensor coire.

Cor na h-Sgàineadh a chur Code Gnìomhach

Cor na h-a chur Faul Code Gnìomhach:

  • IMF 0 Tha suidheachadh nuair a bhios an Motor / Generator astar nas motha na tha ceadaichte àbhaisteach raon.
  • IMF 2 Tha suidheachadh nuair a bhios an Motor / Generator luaths eadar-dhealaichte seach Transmission Input Cas astar na gaoithe le còrr is 100 RPM airson co-dhiù 10 seconds.
  • IMF 3: Set when the resolver circuit is shorted to ground.
  • IMF 21: Set when a resolver signal line short to 12-volt battery or ground is detected.
  • IMF 22, 24, 25 air an cur nuair a bha an measgachadh de Analog-gu-didseatach converter comharran luaidh air dìth cothromachaidh.
  • IMF 27 Tha suidheachadh nuair a bhios an Inverter detects mearachd rè a 'chiad seic.
  • IMF 23 Tha suidheachadh nuair a tha Analog-gu-converter toradh didseatach mearachd comharra airson 100 MS.
  • IMF 26 Tha suidheachadh nuair a bhios an cuairteachadh a sensor astar nas motha na 6000 1 airson mion- 10 MS.

Fallback Nuair Sgàineadh Code 4 air a chur na cumhaichean a leanas a 'tachairt:
• Amber "Check Hybrid" solas illuminates.
• Sgàineadh a stòradh ann Hybrid Control Module (hcm) memory.
• Electric Motor/Generator Assist and Regeneration are disabled; ge-tà, àrd-bholtaids relays fhathast cumhachd.
• HCM continues to control the hybrid vehicle in a diesel-only mode.
• Transmission dearmad tòiseachadh gear gu 1d.

Cor na h-Sgàineadh a chur Code tàmh

-Mhàin tàmh sgàinidhean Faodar fhuadach à Transmission Electronic Control Aonad (TECU) no hcm eachdraidh a 'cleachdadh ServiceRanger. Tha TECU fèin-obrachail a 'glanadh na sgàinidhean bho eachdraidh an dèidh 200 hours. Tha hcm fèin-obrachail a 'glanadh na sgàinidhean bho eachdraidh an dèidh a' choire air a bhith na tàmh airson 200 hours

Tha seo a 'choire còd a bhith air adhbharachadh le sam bith de na leanas:

MY08

  • IMF 0
    • Long leudachadh ìrean dh'fhaodadh feum a-rithist a 'cleachdadh na seirbheis breicichean gus astar an carbad
  • IMF 22, 24, 25, 27
    • Inverter
  • IMF 2, 23, 26
    • Inverter
    • Motor / Generator
    • Resolver Uidheaman-eich eadar na Motor / Generator agus Inverter

MY09

  • IMF 3, 21
    • Inverter
    • Resolver Harness between the motor/generator
      and Inverter
  • IMF 2, 22, 23, 24, 25, 27
    • Inverter
    • Motor / Generator
    • Resolver Uidheaman-eich eadar na Motor / Generator agus Inverter
    • Water in Inverter or Resolver wire connector

Sgàineadh Code 4 – Motor / Generator Chuairteach Gaoithe Sensor Test

Comharrachadh phàirt MY08 System:

Delphi 56-Way Mating Connector View

56 Delphi-Way co-aonadh an ceanglaiche an View

Eaton Transmission Resolver Harness View

Resolver Uidheaman-eich View (Beulaibh Taobh)

NOTE: Coimheadaibh air an Eaton Hybrid pàirtean agus ceanglaiche Àite Àiteachan airson an ceanglaiche ann MY08 Systems

Eaton Fuller Inverter motor generator resolver connection

Comharrachadh phàirt MY09 System:

Deutsch 40-Way Mating Connector View

Deutsch 40 Way co-aonadh an ceanglaiche an View

Eaton Terminal Side - Harness Connector Resolver Deutsch 6-pin connector

Eaton Terminal Side – Harness Connector Resolver Deutsch 6-pin connector

NOTE: Coimheadaibh air an Eaton Hybrid pàirtean agus ceanglaiche Àite Àiteachan airson an ceanglaiche ann MY09 Systems.

Eaton invertor motor generator resolver MY09

CHEUM 1. Lorg airson Gnìomhach no tàmh coire code inbhe.

  1. Ath-bhreithneachadh agus a 'leantainn na Sìde & rabhadh.
  2. Fhaighinn air ais Gnìomhach coire còdan agus FMIs ServiceRanger le bhith a 'cleachdadh na 9 Way-Breithneachaidh ceanglaiche.
  3. prìomh dheth.
    Danger: Faicibh High-Voltage Service Shutdown and Power-Up Procedures. Lean na modhan-obrach a sheachnadh clisgeadh, losgadh no bàs bho dhroch làimhseachadh bholtaids àrd-.
  4. Seinn Electrical Pretest agus Hybrid Electrical Pretest. (MY09 only)
  5. Check Inverter part number. (MY09 a-mhàin)
    • If Inverter is part number 4306453, contact Eaton Call Center at 1-800-826-HELP (4357)
  6. Dè FMIs tha an làthair?
    • MFIs 22, 24, 25, no 27 tha liosta, an àite an Inverter, an uair sin a 'dol gu Ceum 4.
    • Ma FMI 2, 23, no 26 tha liosta, a 'dol gu Ceum 2.
    • Ma FMI 3 no 21 clàraichte, a 'dol gu Ceum 6.
    • Ma FMI 0 clàraichte, Using ServiceRanger select the Advanced Product Functions and download the TECU and HCM snapshots then contact Eaton at 1-800-826-HELP (4357) (MY08 only). Rach gu ceum 7 (MY09 only).

CHEUM 2.Verify leantainneachd Resolver agus Inverter phàirtean.

  1. prìomh dheth.
  2. Disconnect the Low-Voltage Connector at the Inverter.
  3. Inspect for water intrusion inside wire connector.
  4. (MY08 a-mhàin) Tomhais Resolver aghaidh aig 56 ceanglaiche-Way Uidheaman-eich eadar na leanas prìnichean:
        • pin 55 gu Pin 56
        • pin 53 gu Pin 54
        • pin 51 gu Pin 52

      Nota: Gu socair a 'lùbadh an Inverter 56 Way-ceanglaiche Uidheaman-eich faisg air an ceanglaiche an fhad' sa 'cumail sùil air cur an aghaidh luachan.
      Resistance raointean airson na prìnichean tha:

      • Pins 55 gu Pin 56: 10.5-8,6 ohms
      • Pins 53 gu Pin 54: 34-28 ohms
      • Pins 51 gu Pin 52: 27-23 ohms
    • Ma tha na h-àrd-seasaimh a lorg, agus FMI 2 'S e Gnìomhach, contact Eaton at 1- 800-826-COBHAIR (4357).
    • Ma tha na h-àrd-seasaimh a lorg, agus FMI 26 no 23 tha Gnìomhach, an àite an Inverter, an uair sin a 'dol gu Ceum 4.
    • Ma aghaidh tha taobh a-muigh de raon airson gin de na leughaidhean, a 'dol gu Ceum 3.

4. (MY09 only) Determine if resistance for the Resolver at the 40-Way Harness Connector between the following pins is within the range listed:

  • pin 30 gu Pin 40 is 8.6–10.5 ohms
  • pin 28 gu Pin 38 is 28–34 ohms
  • pin 29 gu Pin 39 is 23–27 ohms
    Nota: An auto-eadar didseatach gath / ohm meatair gum feumar a chleachdadh.

    • Ma aghaidh tha taobh a-muigh de raon airson gin de na leughaidhean, a 'dol gu Ceum 5.
      • If resistance is within range, a 'dol gu Ceum 3.

CHEUM 3. Dearbhaich leantainneachd Resolver Uidheaman-eich circuitry.

  1. prìomh dheth.
  2. Disconnect 6-Way Motor / Generator Resolver ceanglaiche.
  3. (MY08 only) Tomhais an Resolver aghaidh aig an 6-Way ceanglaiche Uidheaman-eich eadar na leanas prìnichean:
        • pin 5 gu Pin 6
        • pin 1 gu Pin 3
        • pin 2 gu Pin 4

      Nota: An auto-eadar didseatach Volt / Ohm Meter gum feumar a chleachdadh.
      Resistance raointean airson na prìnichean tha:

      • Pins 5 gu Pin 6: 10.5-8,6 ohms
      • Pins 1 gu Pin 3: 34-28 ohms
      • Pins 2 gu Pin 4: 27-23 ohms
    • Ma tha na h-àrd-seasaimh a lorg, chàradh fosgailte acfhainn eadar an Inverter 56 Way-ceanglaiche agus na Motor / Generator 6-Way Resolver ceanglaiche, an uair sin a 'dol gu Ceum 4.
    • Ma aghaidh tha taobh a-muigh de raon, an àite an Motor / Generator, an uair sin a 'dol gu Ceum 4.

3. (MY09 a-mhàin) Measure Resolver resistance at the 40-Way Harness Connector between the following pins:

  • pin 38 gu Pin 40
  • pin 38 gu Pin 3
  • pin 28 gu Pin 40
  • pin 28 gu Pin 3
  • pin 28 gu talamh
  • pin 38 gu talamh
  • pin 30 gu talamh
  • pin 40 gu talamh
    • Ma aghaidh tha e fosgailte no Ol, àite Inverter.
    • Ma tha an aghaidh rud sam bith eile seach Ol, a 'dol gu Ceum 4.

CHEUM 4. (MY08 a-mhàin) Dearbhaich càradh.

  1. prìomh dheth.
  2. Connectors a h-uile ath-cheangal agus an droch bhataraidh càball.
  3. prìomh air.
  4. còdan soilleir, fhaicinn Soilleir tàmh sgàinidhean.
  5. Stiùir an càr agus a 'feuchainn ri ath-chruthachadh a' chòd.
  6. Lorg airson còdan, fhaicinn Faic dèanadach agus neo-ghnìomhach sgàinidhean
    • Ma eil còdan, deuchainn crìochnaichte.
    • Ma tha Sgàineadh a 'Chòd 4 a rèir coltais, Eaton fios aig 1-800-826-COBHAIR (4357).
    • Ma tha an còd eile seach 4 a rèir coltais, fhaicinn Sgàineadh Code clàr-innse Clàr-.

CHEUM 4. (MY09 only) Dearbhaich leantainneachd Resolver Uidheaman-eich circuitry.

  1. Disconnect the 6-Way motor/generator Resolver Connector (the connector going into the motor).
  2. Tomhais an Resolver aghaidh aig an 6-Way ceanglaiche Uidheaman-eich eadar na leanas prìnichean:
    Nota: An auto-eadar didseatach gath / ohm meatair gum feumar a chleachdadh.

    • pin 1 gu Pin 3
    • pin 1 gu Pin 4
    • pin 2 gu Pin 3
    • pin 2 gu Pin 4
    • pin 1 gu talamh
    • pin 2 gu talamh
    • pin 3 gu talamh
    • pin 4 gu talamh
  3. Ma aghaidh tha e fosgailte no Ol, repair wiring between Resolver and Inverter.
  4. Ma tha an aghaidh rud sam bith eile seach Ol, replace the motor/generator then go to Step 8.

CHEUM 5. (MY09 a-mhàin) Measure resistance of Resolver circuit at motor/generator.

  1. Disconnect 6-Way Resolver wire connector at motor/generator.
  2. Determine if resistance on the following pins falls within the listed range:
    • pin 1 gu Pin 2 is between 28–34 ohms
    • pin 3 gu Pin 4 is between 8.6–10.5 ohms
    • pin 5 gu Pin 6 is between 23–27 ohms
  3. Ma aghaidh tha taobh a-muigh de raon, replace the motor/generator (Resolver is not serviceable). After repairs are made go to Step 8.
  4. If resistance is within range, repair wiring between Resolver and Inverter. After repairs are made go to Step 8.

CHEUM 6. (MY09 only) Verify the resistance at the Inverter.

    1. prìomh dheth
    2. Disconnect 40-Way Low Voltage Connector at the Inverter.
    3. Measure Resolver resistance at the 40-Way Har-ness connector between the following pins:
      • pin 28 gu Pin 1
      • pin 28 gu Pin 6
      • pin 29 gu Pin 1
      • pin 29 gu Pin 6
      • pin 38 gu Pin 1
      • pin 38 gu Pin 6
      • pin 39 gu Pin 1
      • pin 39 gu Pin 6
        Nota: An auto-eadar didseatach gath / ohm meatair gum feumar a chleachdadh.
    4. If resistance is open or OL replace inverter. After repair is made go to Step 8.
    5. If resistance is anything other than OL go to H.

CHEUM 7. (MY09 a-mhàin) Verify overspeed condition by test driving the vehicle.

  1. 1. Test drive vehicle to verify an overspeed condition. This may require a downhill road condition, verify with customer the road condition when fault was set.
    • Ma FMI 0 is set in a true overspeed condition, vehicle will need to be slowed down to prevent overspeed condition.
    • Ma ghabhas, update HCM software version number 672 or higher. If vehicle has HCM with primary hardware version 4306455, the most current software version available is 663. To update software version 672 or higher requires an HCM with hardware version 4306473. Hardware version number can be found in Service Ranger under Product Configurations, hcm, Primary Hardware Version.

CHEUM 4. (MY09 a-mhàin) Dearbhaich càradh.

  1. prìomh dheth.
  2. Connectors a h-uile ath-cheangal agus an droch bhataraidh càball.
  3. prìomh air.
  4. còdan soilleir, fhaicinn Soilleir tàmh sgàinidhean.
  5. Stiùir an càr agus a 'feuchainn ri ath-chruthachadh a' chòd.
  6. Lorg airson còdan, fhaicinn Faic dèanadach agus neo-ghnìomhach sgàinidhean
    • Ma eil còdan, deuchainn crìochnaichte.
    • Ma tha Sgàineadh a 'Chòd 4 a rèir coltais, Eaton fios aig 1-800-826-COBHAIR (4357).
    • Ma tha an còd eile seach 4 a rèir coltais, fhaicinn Sgàineadh Code clàr-innse Clàr-.

sam bith sgaoilidh phàirt feumaidh tu feumaidh sinn e! Aon latha luingeis ri fhaotainn, an t-saoghail.

FEUMAIDH taic an-asgaidh bho aon de ar n-eòlaichean?

Call-NIS
post-d thugainn